9号彩票
您好!欢迎来访东营博诚长臂挖掘机出租公司!关于我们 | 联系我们 | 在线留言
全国统一服务热线
18766733030
联系我们
联系人:王经理
联系电话:18766733030
地址:山东省东营市
租赁动态

做好挖掘机的保养才能使用长久!

日期:2018-08-24   来源:/
不管什么样的机器,都需要保养才能使用长久,挖掘机也不例外,保养举足轻重,不可忽视。对于不熟操作的人员来说,要多看挖掘机注意事项,多看保养手册,了解挖掘机加长臂基本情况,知道多少小时换机油,换空气虑清器,行走的根据行走的路程来决定,如果空气滤清器有很多灰,就要及时清理,机油要更换稠化机油,适用即可,液压系统有地方漏油也要及时处理,油箱要做好保温,该润滑的地方要经常打黄油等等。从最基本的打黄油开始了解。
No matter what kind of machine, need to be maintained to use for a long time, excavator is no exception, maintenance is very important, can not be ignored. For those who are not familiar with the operation, it is necessary to pay more attention to the matters needing attention of the excavator, to look at the maintenance manual, to understand the basic situation of the extended arm of the excavator, to know how many hours to change the oil, to change the air cleaner, and to walk on the basis of the walking distance. If the air cleaner has a lot of ash, it should be cleaned up in time and the oil should be replaced with a thick one. Chemical engine oil, applicable to the hydraulic system where there is a leakage must be dealt with in a timely manner, oil tank to do a good job of insulation, the lubrication of the place to often beat butter and so on. Learn from the most basic butter.
采用润滑油(黄油)可以减少运动表面的磨损,防止出现噪声。润滑脂存放保管时,不能混入灰尘、砂粒、水及其它杂质;推荐选用锂基型润滑脂G2-L1,抗磨性能好,适用重载工况;加注时,要尽量将旧油全部挤出并擦干净,防止沙土粘附。
长臂挖掘机
The use of lubricating oil (butter) can reduce wear on the surface and prevent noise. Dust, sand, water and other impurities should not be mixed into the grease during storage; G2-L1 is recommended for lithium-based grease, which has good wear resistance and is suitable for heavy load conditions; when filling, the old oil should be extruded and wiped clean as far as possible to prevent sand adhesion.
如果长期不打销子和套子要被磨大,慢慢的销子就会断或者套子被磨烂。打黄油要养成习惯,挖机的大毛病就是这些小问题积累而来的。一般活动量最大的地方,磨损会比较大,因此打黄油的频率也会适当高些。特别是挖斗上的6个黄油嘴最重要,因为活动量最大,所以每作业8小时就应该加注一次黄油,另外就是挖掘机标准大小臂连接处3个,大臂上5个,大臂油缸下2个 一天加注一次最好,24小时打一次也没事,主要看干什么活,这个自己掌握。回转转盘一般每作业250小时加注一次,这个不能频繁加注、一次不能加注过多,因为转盘有防尘防水油封  过多 过频繁加注会损坏油封。
If the pin and sleeve are to be worn for a long time, the pins will be broken or the sleeves will be worn away. It is necessary to build a habit of beating butter. The major problem of digging machines is the accumulation of these small problems. In general, where the maximum amount of activity is, wear will be larger, so the frequency of butter will be higher. Especially the six butter nozzles on the bucket are the most important, because the activity is the largest, so every 8 hours should be filled with butter, and the other is the excavator standard arm joints three, five arms, two under the arm cylinder filling a day best, 24 hours a time is also okay, mainly to see what work, this from You have mastered it. Rotary disc generally every 250 hours to fill a time, this can not be frequent filling, one can not add too much, because the rotating disc has dust-proof waterproof oil seal too much frequent filling will damage the oil seal.
其实挖掘机正常工作,一般情况每天加注黄油,尤其是铲斗轴,每天检查机油,液压油,随时清理空滤。另外操作上注意按加长臂挖掘机操作规程作业。
In fact, the excavator works normally, the general situation every day to fill butter, especially the bucket shaft, every day check the oil, hydraulic oil, at any time clean up the air filter. In addition, attention should be paid to the operation of long arm excavators.
有了长臂挖掘机上面的小总结,希望对广大客户有所帮助,如果有什么不理解的或者寻求帮助的请点击我们的官方网站:或者来电咨询,我们会尽全力为您解决
With a brief summary of the long arm excavator, I hope it will be helpful to our customers. If you have any incomprehension or ask for help, please click on our official website: or call for advice. We will try our best to solve it for you.

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】

友情链接:幸运飞艇  幸运飞艇  幸运飞艇  幸运飞艇开奖直播  幸运飞艇  幸运飞艇  幸运飞艇彩票  

免责声明: 本站资料及图片来源互联网文章,本网不承担任何由内容信息所引起的争议和法律责任。所有作品版权归原创作者所有,与本站立场无关,如用户分享不慎侵犯了您的权益,请联系我们告知,我们将做删除处理!